0517-86918678

Address：No. 4-4 East West Road, Jinhu County Industrial Concentration Zone, Huaian City, Jiangsu Province
Tel：0517-86918678
Fax：0517-86918679
Email：zhongweick@163.com
Post Encoding：211600

Home /Product /Level instruments /Floating Ball Level Controller

Floating Ball Level ControllerFloatingBallLevelController

Top mounted float level controller

ZW-UQK series Top mounted float level controller Composed of a floating ball, rod etc.. The connecti…

Description：

、產品概述：">Productoverview:

ZW-UQK series Top mounted float level controller

、插桿等組成

。">Composed of a floating ball, rod etc..

，浮球根據排開液體體積相等等原理浮于液面

，當容器的液位變化時浮球也隨著上下移動

，由于磁性作用

，浮球液位控制器的干簧受磁性吸合，把液面位置變化成電信號

，通過顯示儀表用數字顯示液體的實際位置

，浮球液位控制器從而達到液面的遠距離檢測和控制。">The connecting flange is arranged in the container on the top of the floating ball by liquid volume equal according to the principle of floating on the surface, when the liquid level change container when the float with the next movement due to the magnetic effect, float level controller reed by magnetic attraction, the liquid level change into electric signal by using digital display instrument according to the actual position of the liquid, float level controller to achieve remote monitoring and control level.

、工作原理：">Two, work principle:

。">ZW-UQK series <strong> top mounted float level controller</strong> is composed of a floating ball assembly and transformation of two parts. ，使連桿端部的磁鋼做相反方向移動

。">When the measured level changes, the floating ball will move up and down, to the end of the connecting rod magnet do the opposite direction. ，船用浮球液位控制器是轉換機構中的磁鋼迅速被排斥到另一邊

，使微動開關接通或斷開，輸出開關信號

，船用浮球液位控制器用以實現報警或自動控制

。">Reach level two control points, through the magnetic repulsion of the marine float level controller is the conversion mechanism of the magnetic steel quickly rejected to the other side, the micro switch is turned on or off, the switch signal output, to achieve the alarm or automatic control for marine float level controller.

Three, application:

，鋁

，不銹鋼等材料不起腐蝕作用的容器內夜的控制

。">ZW-UQK series <strong> top mounted float level controller</strong> is suitable for copper, aluminum, stainless steel and other materials that do not corrode the container control night. ，控制器輸出觸電開關信號

，實現液位的報警或啟停電泵。">When the liquid level reaches high, lower limit position, the controller output electric shock switch signal, realize the liquid level alarm or pump power. ，化工等工業部門中

。">It can be widely used in petroleum, chemical industry etc..

Four, main features:

、xj****的設計和嚴格的制造工藝為產品質量提供了可靠的保證

。">1, advanced design and strict manufacturing process provides a reliable guarantee for product quality.

、PP

、PVC塑料，強度高

、耐腐蝕性好

。">2, the shell is made of ABS, PP, PVC plastic, high strength, good corrosion resistance.

，耐油

、酸、堿

，抗蝕能力******

。">3, cable with special materials, oil resistant, acid, alkali, corrosion resistance is superior.

、性能可靠

。">4, simple structure, reliable performance.

，無任何誤動作

，可靠性高。">Stable and reliable output on and off switch signal, no misoperation, high reliability.

、安裝簡捷

，調試方便，上下移動定位重塊

，即可隨意調節液面控制范圍

。">5, simple installation, convenient debugging, on the mobile positioning block, can freely adjust the liquid level control range.

、技術參數：">Five, technical parameters:

、額定電流：16A-120VAC

；10A-300VAC；0.6A-150VDC；">1, rated current: 16A-120VAC; 10A-300VAC; 0.6A-150VDC;

、觸點輸出：兩個獨立的SPDT觸點

；">2, an independent contact output: SPDT contact;

；">3, contact material: silver (Ag);

、本體材質：精密氧化鋁陶瓷；">4, body material: precision alumina ceramics;

、開關外殼：壓鑄鎂鋁合金表面亞光聚亞***酯涂層

；">5: die casting magnesium alloy shell, switch surface polishing of polyurethane coating;

；">6, the rated temperature: Standard Type: -40~250 ~ C;

、高溫型：≤370°C；">7, high temperature type: 370 ~ C;

、壓力等級：ANSI Class150

、300、600

、900LB、PN1.0

；">8, ANSI Class150, pressure rating: 300, 600, 900LB, PN1.0;

、過程連接：法蘭連接DN50、80

、100

；2'~4〞ANSI；">9, process connection: flange connection, DN50 80, 100 2'~4 ANSI; ";

、介質密度：≥0.40g/cm3

；">10, medium density: 0.40g/cm3;

、1/2'NPT 內螺紋

；">11, electrical interface: M20 * 1.5, 1/2'NPT internal threads;

；本安型ExiaⅡCT6

；">12, flameproof explosion-proof grade: Exd II BT4 II CT6 Exia intrinsically safe;

。">13, protection grade: IP65.

、安裝使用說明：">Six, installation instructions:

External installation:

，否則開關會因進水口的波動而造成誤動作

。">1, the installation location should be away from the water inlet, otherwise the switch will malfunction caused by the fluctuation of water inlet.

。">2, if the float level switch device in the vessel wall, can be installed L type steel bracket.

、若開關裝置于攪拌區域，可安裝防波管或防波擋板

。">3, if the switching device can be installed in the stirring area, wave tube or wave baffle.

、選擇管的內徑大于浮球直徑的法蘭連接管。">4, the selection of pipe flange diameter greater than the diameter of the connecting pipe of the floating ball.

、配線時建議使用多蕊電纜

。">Recommend the use of multiple core cable wiring, 5.

。">6, controlled by the line load must match the float switch contact capacity.

、被測液體的比重須***大于浮球比重。">7, the measured liquid proportion must be greater than the proportion of floating ball.

、浮球的動作點已按客戶訂貨要求在出廠時調整好

，請不要隨意調整浮球位置。">8, the floating ball movement has orders in the factory is adjusted according to the customer, please do not arbitrarily adjust the float position.

Internal wiring installation:

、當浮球開關使用在有馬達

、繼電器、螺管線圈等有電感性負載的電路中

，建議在負載兩端并聯保護線路如：RC(緩沖器)

、變阻器、二極管等

。">1, when the float switch used in motor, relay, solenoid coil circuit has an inductive load, in parallel across the load protection circuit such as: RC (buffer), rheostat, diode etc..

、馬達或電磁開關。">Note: please do not float switches are directly connected to the electromagnetic valve, motor or solenoid switch.

、當浮球開關使用在有電容器

、熾熱燈泡、很長的電纜線等電容性負載中時

，在開關的觸點間將產生一個驟升電流

；建議在浮球開關兩端并聯保護線路，如限流電阻器或突波吸收器等

。">2, when the floating ball switch is used in capacitors, hot bulb, long cable and capacitive load, will produce a surge current in the switch contacts; in the float switch is connected in parallel with the protection circuit, such as current limiting resistors or surge absorber etc..

、配線及接點說明:">Seven, wiring and contact instructions:

，將電纜線從入線口穿進

，并鎖緊入線口電纜固定頭，根據銘牌及接線板端子臺上的標識將接點線接入對應的端子上

。">1, open the box, the cable from the inlet through, and lock line inlet cable fixed head, according to the nameplate and wiring board terminal station logo on the terminal of the contact line on the corresponding access.

、接線板端子臺上的標識數字由小到大對應著從上至下各浮球的接點。">From the 2 wiring board, digital identification terminal table corresponding to a contact from top to bottom of the floating ball.

3, float ball joint is divided into three forms:

；">1A said: when the liquid level is higher than the floating ball contact A-C;

；">The 1B said: when the level is below the floating ball contact B-C;

；液位高于浮球時則A-C接點接通

，B-C斷開。">The 1AB said: when the A-C level is below the floating ball contact open, B-C connected; the liquid level is higher than the floating ball when the A-C contact is connected, disconnect the B-C.

、接線完成后請將盒蓋旋緊并將接線口固定

，以確保接線盒防水。">4, please tighten the lid after the completion of the connection and the connecting port is fixed, in order to ensure the waterproof junction box.

、使用注意事項：">Eight, matters needing attention:

、定期清理連桿及浮球上的雜物及污垢（周期視水質而定）；">1, regular cleaning of debris and dirt rod and the floating ball (depending on the water quality and cycle);

、定期檢查各連接部件是否牢固

；">2, regular inspection of all parts are firmly;

，以保證浮球能順利浮動

；">3, should consider the proportion of liquid, in order to ensure the smooth float to float;

；">4, the control circuit load does not overload use (less than the capacity of contact use);

、接線盒電氣接口須***朝下；">5, electrical wiring box interface must be down;

、酸堿性液體中使用請選用防腐型；">Please choose anti-corrosion type 6, alkali liquid;

、浮球與連接桿不得與容器過程連接管相觸碰

。">7, the floating ball and the connecting rod is connected with the container tube shall not touch the process.

Nine, common faults and exclusion:

、故障現象

、原因分析及排除方法浮球不動作">1, failure analysis and troubleshooting of floating ball movement

The liquid proportion is less than the proportion of floating ball to re confirm the proportion of floating ball;

；">The floating ball, and the Water Leakage company to replace the floating ball;

。">The floating ball to remove foreign bodies stuck in foreign body.

，但無信號輸出">2, the floating ball moves, but no signal output

；">The float position offset, adjust the float position;

The magnetic reed switch is damaged, replace the magnetic reed switch.

、信號輸出不正常, 附近有磁場干擾→消除磁場

；">3, the output signal is not normal, to eliminate the magnetic field near the magnetic field interference;

，有異物卡住→清除異物

；">4, maintain the signal, unable to recover, the floating ball can not return, a foreign body stuck to remove foreign bodies;

。">5, there will be a two signal output, ring position, adjusting ring buckle position.

、規格數據表：">Ten, specification data sheet:

Model name	explosion-proof Grade	Medium pressure ( MPa )	Medium temperature (c)	Switching difference ( Mm )	Setting mode	install form	Power & contact Capacity and life
ZW-UQK-01 type		One	One hundred and fifty	Less than 14	Not adjustable	level	Communication： 220V , 1.5A 、">, 110V 、">, 2.5A Direct： 24V , 2.5A 、">, 240V 、">, 0.5A Life： Five *Ten Two
ZW-UQK-01--dIIBT4type	DIIBT4	Four
ZW-UQK-02 type		One	One hundred and fifty	25~250	Level adjustable	level
ZW-UQK-02-dIIBT4type	DIIBT4	Four
ZW-UQK-03 type		One	One hundred and fifty	8~1000	Stepless adjustable	vertical
ZW-UQK-03-Diibt4type	DIIBT4	Four

Eleven, the selection of encoding:

Specification code	Name
ZW-UQK	Ordinary type float level controller (Zhongwei control)
ZW-UQKS	With a self-test type float level controller
	form	Control range			Adjust the way			The installation form	basic form
	-01	10mm			Not adjustable			Side mounted
	-01N	60mm			Not adjustable			Side mounted
	-01T	40mm			Adjustable			Top mounted
	-02	25-550mm			Level adjustable			Side mounted
	-03	8-2000mm			Stepless adjustable			Top mounted
	-04	10mm			Not adjustable			The outer level
		-	Fifty	Flange diameter DN50 or 2
			Eighty	Flange diameter Mao 80 or 3
			One hundred	Flange diameter DN100 or 4					Explosion-proof options
				O		Ordinary type
				D		Flameproof
				E		Intrinsically safe			working temperature
						S	Standard type
						M	Medium temperature
						H	High temperature type
							-.	Medium density g/cm3
							-.	The working pressure of MPa

，尺寸及動作點位置

。">Note: Please specify the specific process of connection, the size and position of action point.

12, design selection and ordering information:

、液面開關裝置型號規格

；">1, the liquid level switch device specifications;

；">2, measuring range;

、工作壓力、溫度

；">3, working pressure and temperature;

、控制裝置材質；">4, material control device;

、特殊要求協商

；">5, the special requirements of negotiation;

、螺栓

、螺母、閥門及密封墊圈等配件

，以便正確選型

。">6, whether the liquid level device supporting the supply vessel flange, bolts, nuts, washers and valve sealing parts, so that the correct selection.

Customer service service commitment:

，負責免費維修

。">1, our level switch series products quality problems within twelve months, responsible for free maintenance.

，我公司負責免費維修或更換

。">2, the warranty period if the products of our company have any quality problems, our company is responsible for free repair or replacement.

、質保期內如用戶使用不當，造成產品損壞

，我公司負責維修

，收取損壞部件成本費。">3, the warranty period if the user use undeserved, cause damage to the product, our company is responsible for the maintenance, collect the damaged parts cost.

、質保期后產品出現質量問題

，我公司負責維修，收取損壞部件成本費

。">4, after the warranty period of product quality problems, our company is responsible for the maintenance, collect the damaged parts cost.

、如用戶需我公司現場服務，對省內用戶我公司服務人員12小時內到達現場

，省外用戶48小時內到達現場

。">5, if the user needs to our service, our company in the province of the user service personnel arrived at the scene within 12 hours, arrived at the scene 48 hours outside users.

Browse：

On A：Self floating ball liquid level controller

Next：Anti float level controller

分享到：

公交车上拨开少妇内裤进入电影,同桌把我下面摸高潮视频,尤物视频在线国产,国产一区二区三区深田咏美,久久婷婷丁香五月综合开心,亚洲高清情侣网站,国产欧美日韩手机在线不卡,丝袜美女污污免费网站,一本色综合久久,seerx性欧美老妇,少妇挑战三个黑人惨叫4p国语,91白浆视频在线,影音先锋蜜芽视频,囯产偷拍一区二区三区,水多多凹凸福利视频导航,国产免费A∨在线播放,无遮挡又爽又刺激的免费观看